We sell new, used, refurbished and rebuilt parts for nearly all forklifts, pallet jacks, forklift batteries, chargers and industrial equipment. Forklift Parts Plus specializes in hard to find/identify parts. With over 28 years in business and 100's of years of cumulative experience in parts and service we have the expertise to offer you the best options.
Recently Asked Questions
Question: When looking at a battery model number (such as 12-100-15) what do the numbers stand for.
Technician: 12 is # of cells, each cell is 2 volts, so 12 x 2=24 volt
100 is amp hour cap per pos plate
15 is total number of plate per cell, the use of this is 15 plates-1=14/2=7
the 7 is the number of pos plates per cell
7 x 100=700 ah
you have a 24 volt 700 amp hour battery
Question: Mitubishi Grey Market Fork lift.....
Steering box is out.
The steerign box contains an aluminum tube with ball bearings inside of it. The tube failed and the ball bearings came out. It no longer steers at all. I'm trying to connect with someone who can find a replacement tube, or maybe even the entire steering box.
The following numbers are on placards (with Japanese lables) on the lift:
I'm not sure which is model number or serial number.
The diesel motor runs fine....just the steering is out.
Technician: call our parts dept
Question: GC25E Daewoo propane forklift with a dead battery. Is this a special battery or can a car battery be used, if so do you sell one?
Technician: automotine style battery should be fine, check size and post loication
Question: We have a 1965 Yale serial #AG094577 with a Continental 4 Cyl engine #F135A 3052 S 324
Installed New Plugs, Wires, Air Filter and Battery. Removed the Needle Valve in the Jet cleaned and reset to 1 full turn open. Engine runs but only with the help of the choke (About Half)If I release the choke engine will Spit, Sputter & Backfire. My Question is - Timing Issue? If so I don't see where or what to loosen to Advance or retard the timing.
Thanks for your time.
Technician: carb worn out, air fuel mixture-- are the plugs blackish out white, the whole distr. should turn to adj timming
Question: i have a 24volt battery in an old Clarke fork lift pallet type.the battery is a 600ah,12 small battery's,its time for a new charger,i found a Lester charger 9690 60amp DC 24v will this work or should it be smaller or larger?
Technician: 60 amp is up to 330 amps
120 amp-up to 660 amp
so your 60 amp will not fully charge the battery
Question: I have a lift mod.# HLF15TT, ser# HBoo12131 type is E160728. Is there an access panel on trans to adjust bands, reverse has gone out. Was delay before going into reverse, now you might get a slight roll and then nothing. electric good and solenoids are good and strong. Pulled spool valve all "o"rings and back up are good. ???
Technician: no external adjustments, common is bad internal seals, need to remove transmission
Question: whats the gravity spec for a 24 volts commerecial battery?.
Technician: 1275 fully charged
Question: I have a mis and I have no info on my forklift. Is there a place I can go and give my numbers off my forklift to get info. It is a 4 cylinder gas. Serial #Y4048650 engine serial # 39286
Technician: pull spark plug wire to locate the cylinder that is not firing..and/or take a compression test..
Send us a pictur and we can id your motor
Question: model number s40xl lp only how long to replace water pump assy? how long does it take?
call or text or email.
Technician: That unit has more then one motor option, but it should take about 3 hours to replace the water pump
Question: get pin out from tilt ram
Technician: If it dosn't want to come out, unscrew the piston and leave the clevis on the mast
Question: Is there such a thing as non-scuffing or non-marring fork truck tires? Can you give me an example (link) of one such tire if you carry them
Technician: Yes we have them, call 877-411-Lift ask for parts..
Question: I am looking for a Pick up Coil for a mitsubishi forklift model FG30
Technician: We have them, call 877-411-Lift ask for parts
Question: We have a 1998 Mitsubishi FG35G Forklift. We need a cab cover for winter. I have contacted Martin Cab. Is there anyone else that makes a Steel and Vinyl Cab Cover for this forklift?
Technician: We do offer other options call our parts department at 877-411-Lift
Question: WHAT IS THE PROPER WAY TO MATCH UP ELECRTIC FORKLIFT CHARGERS WITH BATTERIES?ON A 700AMP BATTEERY WILL A 850 AMP CHARGER WORK OR WILL A 500AMP CHARGER BE THE WAY TO GO ?
Technician: The 850 will have the ability to fully charge your battery and should not over charge
Question: have an older model Yale forklift am trying to figure out how to read the model number so i can tell the year it was made, where, and also if it can tell you the engine make and or size. here is the information i got off of the tags make: yale type: G Industrial Truck 357A, #5021352-11 Model #: GP050RDJVAE086 Serial #: N434037
Technician: GP050RDJVAE086 Serial #: N434037
gm or mazda motor
Question: I have a Clark C500 25 propain powered tow motor that is running like it is missing but the plugs seem good and the distributer cap does not seem that bad and have already tried switching tanks and think it might be the carb that the tank runs to. took the cover off and it was real greasy and dirty inside and cleaned it out but didnt make much of a difference. is there a kit for it or do you change the whole thing? and is there any thing i am missing i should check? I am used to diesel not propain.
Technician: Vaporizer and or carburetor call our parts department for pricing on kit and complete units
Question: I tried to fill out form to request a qoute and it told me my e-mail is to long. what are my other option other than calling?
Technician: you can E-mail to Lifttruck@msn.com
Question: where are the brakes on a Mitsubishi model FGC25k forkilift. also my e-mail address is to long above
Technician: They are automotive style, you need to remove the tire, axle, hub bearing and brake drum
Question: The motor started good then shut down, probably burned off the fuel that was in the lines?? then motor shut down. We noted there was an accumulation of water in diesel fuel tank from not operating for the past 3 yrs. drained all fuel and replaced filters, can't get 6cyl motor started, has CAV Fuel Pump please suggest how to get this unit back running or starting procedure
Technician: With a diesel you need to bleed the system, there is a manual pump somewhere in the system and bleeder screw at the injector pump and filter also the injector lines will needed to be purged or air, not as bad as it sounds,but need to be done..Regards
Question: I have a forklift with a continental 6 cylinder but i dont know what the engine size is the forklift is a V60B sereal number is 89M833
Question: Is 501446 a valid P/N for a tire rim for a Manitou lift?
Technician: Yes this is a good number..$845.00 2-3 weeks
may be able to do for less..call ask for Sergio..he can get the infor to see if wde can make this rim
Question: I have a lift all MT80 TOW
serial#78656 need to know what engine I have in that and what the float level would be on that carb, the carb is a carter motor craft.
Technician: That should be a ford 300 (4.9)we have e-mailed you the card float spec
Question: We have a Clark type "G", forklift model # CY2015QA257.We need some bearings for the steering gearbox. Can you help us? I'm working on this & I can't hear on the phone due to bad hearing... if you need, the given phone # should reach the sales manager.
Technician: Hello, sure thing - we will give you a call shortly to assist further.
Question: I would like a quote for replacement vinyl suspension seats, and their upper and lower replacement cushions the following models of Hyster lift trucks. E50XM, E50XM2,E50Z and the E50N.
Technician: Hi, we're happy to send you a free quote for your forklift seats. A parts tech will be contacting you shortly, or feel free to call us at 877-411-5438.
Question: i have a allis chalmers 2000 lb forklift im looking for a rear tire model acc20 serial no. 17209528 how do u measure what size to order thanks
Technician: Tire need 3 dimentions
something like 16 x 5 x 10.5
if you call our parts dept with the make and model they can tell you what size it should be..
Question: I have 42 Yale trucks at my facility
and I need a faster easier way to get Yale parts. Can your site help me?
Technician: Yes! We would like to earn your business..call us with your request and we will quote you over the phone..we will have a parts tech call you.
Question: I'm looking at purchasing a used battery for TCM FORK LIFT MODEL #FCB10H2
36 VOLT MODEL NOGTC1118-865T1 BATTERY TYPE LA.
Technician: Sounds like a 18-85-21,850 ah. We will need to confirm dimentions and voltage. A tech will contact you shortly.
Question: We are looking at purchasing a used battery for our Toyota counter balance.
Below is the information for this unit:
Toyota Counter Balance
Model LA24K 946 ( 24 85 13 )
Serial Number 010328
Dimensions: 38.5 L 21.5 W 25 H
Connector Type SB 350 Grey
Can you please advise the cost associated with purchasing a used battery for this unit?
Technician: A parts tech will be contacting you shortly with pricing.
Question: Looking for a break down between engine and bell housing.
Technician: Hi Jim,
We will need more information about your specific forklift (make, model and serial number) please call in with this and we will try to help you.
Question: I think 3 of our Yale forklifts need new batteries. I don't have the serial number but I've got the make/model.
Technician: No problem. We'll help you identify the right battery.
Back to Top
Question: I'm not sure what the problem is on our forklift. It's not tilting but that's about all I know. Any suggestions?
Technician: The best thing to do is give us a call and one of our forklift technicians will can walk you through some steps to help diagnose the issue.
Question: I'm not sure if my forklift model is still manufactured and the parts might be very difficult to find. Can you still help?
Technician: Sure. You'll be surprised what we can find. Just fill out the form on our site or give us a call and we'll try to find the best way option: new, used or rebuilt.
Question: We have several different makes of forklifts in our warehouse: Hyster, Yale, Toyota and Nissan mostly. We need several parts for each, can we just call and get a quote?
Technician: Yes, please do. You can give us a call at 877-411-5438 or call 915-778-0058 to speak with a forklift parts specialist.